issue with older JD gator 6x4
when in neutral lots of power, put in gear then have no power. lucky if goes 5 mph. any ideas???
View ArticleClik here to view.
Texas
Howdy from Texas.... 855D in shop being lifted 8" with 32" Terminators, 3000# Warn on the nose. We built a custom roof, aluminum deck plate powder coated black. It features inset pockets all around for...
View ArticleHelp with a 2008 Gator TX please...
My '08 TX no longer runs at normal "top end" speed. After driving for less than a minute, there is a dramatic power loss and will eventually slow to a stop. Then, it will idle only. Adding gas pedal...
View ArticleTire Pressure Recommendation
My HPX originally had 24x9x10 TurfTrac tires and the manual recommends 7 psi front and 14 psi rear. Now I have AllTrails (25x9x12 front and 25x11x12 rear) mounted on factory 12x7 and 12x8 rims that I...
View Article825i engine
I have a 825i engine that has a spun bearing or some other low end damage. The engine was still running well just had a knocking noise before I replaced it. This engine is complete with the wiring...
View ArticleIdentification Problems.
I just recently purchased a gator but got no books with it. the only thing i have is its identification # w004x2x098422. could someone tell me how to look up its information?
View Article2001 6x4 fuel pump runs constantly
I am anew member and recently picked up a 2001 6x4, the fuel pump runs constantly is this normal? Thanks for the help
View ArticleYear of my 550 gator ?
Model 550XUV Dom 050413 Does this mean it is a 2013?. The guy I bought it from said it was a 2014. Or does the Product ID # tell you the year? Or does the CSN number tell you the year?
View Article825i vs the other brands
I have been looking at UTV's for working on my property instead of having to drive a tractor everywhere.Mainly it will be for cutting firewood so the bed will be setup with all my chainsaw...
View ArticleClik here to view.
Trouble Code Retrieval
A while back someone was looking to retrieve trouble codes without going to the dealer. While investigating something on a Progator 2020, I ran across the following in the operator's manual. It would...
View ArticleClik here to view.
More carnage!
Well I'm not sure if its the tracks, power steering, or my driving but likely a combo of all 3 lol, ripped the frame mounts off the frame on the right side for the steering rack and broke the rack on...
View Article'98 6x4 frame off restoration
Hi, guys, just beginning a total restoration of an old 6x4 I've acquired. Frame is going to need some significant repair, which I think I've got a handle on. Last bit of stripping down to do is...
View Article4wd will not engage
hey guys I'm new to the gator,I just bought a 2012 rsx850i with 76 hrs on it. It seems to have an issue with the 4wd,I hear the actuator in 4wd then in 4wd lock,but the frt whls wont turn(gator on jack...
View ArticleCover for Gator
My Gator TE is about to go in for painting. I'm worried that the paintwork will get damaged as I'm towing it down the motorway at 70mph. Does anyone know of a good cover suitable for the Gator that...
View ArticleClik here to view.
rsx850i wont start
I was crawling on a ledge Saturday and ended up flipping into a fairly deep creek on my driver side. the water was almost completely over my seat. of course I immediately cut the key off. we flipped it...
View Article590i S4
Just picked up the new 590i S4 with power steering last Thursday after owning a 550S4 (2012). Although I only put roughly 25 miles on the new unit, I am very impressed with the motor and steering....
View ArticleClutch torque
Does anyone know the torque spec for the main clutch on a 2008 Gator TX ? If so, is there a special procedure ie: High torque to press the clutch on then loosen and re-torque for service ?
View ArticleXUV550 Wiring diagram for accessories
Hi everyone, Im looking for advice regarding wiring accessory electrical items. I haven't had the chance to meter any of the leads that are factory under the dash and near the battery box that JD left...
View Article